MANUEL D'ENTRETIEN POUR MOTONEIGE

MODELS COVERED:

Wildcat 650 (1988-1989)
El Tigre EXT (1989)

This Arctic Cat snowmobile manual is 400 pages.

QUICK REFERENCE DATA

CHAPTER ONE / GENERAL INFORMATION
Manual organization / Notes, cautions and warnings / Safety first / Service hints / Engine and chassis serial numbers / Engine operation / Torque specifications / Fasteners / Lubricants / RTV gasket sealant / Threadlock / Gasket remover / Basic hand tools / Precision measuring tools / Special tools / Mechanic¿s tips / Ball bearing replacement / Oil Seals / Snowmobile operation / Snowmobile safety / Snowmobile code of ethics / Specifications

CHAPTER TWO / TROUBLESHOOTING
Operating requirements / Troubleshooting instruments / Testing electrical components / Engine electrical system troubleshooting / Voltage regulator / Electric starting system (optional on El Tigre EXT) / Fuel system / Engine / Two-stroke pressure testing / Power train / Skis and steering / Track assembly

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Pre-ride checks inspection / Break-in / Correct fuel mixing / Maintenance schedule intervals / Engine oil tank change / Chaincase oil change / Spindle lubrication / Slide suspension lubrication / Speedometer drive adapter / Cooling system / Coolant level check change inspection / Daily maintenance / Drive belt check / Headlight taillight check / Steering bolt / Carburetor jetting / Weekly maintenance / Recoil starter / Ski and runner alignment / Track adjustment / Fuel filter / Water pump belt / Drive chain reverse gear / Cylinder head torque / Tune-up / Compression check / Cylinder head torque / Spark plug plugs / Ignition timing / Dynamic timing / Static timing / Carburetor synchronization / Idle speed / Specifications

CHAPTER FOUR / HIGH ALTITUDE ADJUSTMENTS
Carburetor tuning / Clutch tuning / Gearing / Suspension / Specifications

CHAPTER FIVE / ENGINES
Engine and chassis serial numbers / Engine removal installation / Engine plate and mounts / Engine top end / Cylinder head / Cylinder housing / Pistons / Piston rings / Wrist pins / Connecting rods / Small end bearings / Reed valve / Crankcase / Crankshaft / Pinion gear / Water pump / Specifications

CHAPTER SIX / FUEL AND EXHAUST SYSTEMS
Air silencer / Carburetor / Fuel pump / Fuel tank / Throttle cable / Exhaust system / Muffler / Specifications

CHAPTER SEVEN / ELECTRICAL SYSTEM
Battery / Capacitor discharge ignition CDI / CDI box / Ignition coil / Voltage regulator / Electric starting system / Lighting / Meter assembly / Gauges / Switches / Oil level gauge / Fuses / Wiring diagrams / Specification

CHAPTER EIGHT / OIL INJECTION SYSTEM
Oil pump / Specification

CHAPTER NINE / LIQUID COOLING SYSTEM
Thermostat / Water pump / Heat exchanger / Specifications

CHAPTER TEN / RECOIL STARTER

CHAPTER ELEVEN / DRIVE SYSTEM
Drive unit / Primary sheave / Secondary sheave / Drive belt / Specifications

CHAPER TWELVE / BRAKE, CHAINCASE, JACKSHAFT AND DRIVE AXLE
Drive chain and sprockets / Jackshaft / Drive axle / Front brake / Reverse / Specifications

CHAPTER THIRTEEN / FRONT SUSPENSION AND STEERING
Skis / Front suspension / Shock absorbers / Steering assembly / Specifications

CHAPTER FOURTEEN / TRACK AND REAR SUSPENSION
Rear suspension / End caps / Wear strips / Rear suspension assembly / Suspension and guide wheels / Track / Specifications

CHAPTER FIFTEEN / OFF SEASON STORAGE

INDEX

WIRING DIAGRAMS